Comparison of biogas production from rapeseed and wheat residues in compound with cattle manure
Journal Title: Journal of Agricultural Machinery - Year 2016, Vol 6, Issue 2
Abstract
Introduction Seventy million tons of agricultural crops are produced from 18 million hectares of agricultural lands in Iran every year. Since 80% of the crops (wt. basis) ends up as residues, therefore, about 50 million tons of crop residues are generated annually the majority of which is burnt on field leading to vast emissions of greenhouse gases (GHG) due to the incomplete combustion process. These residues could potentially be transformed into heat energy directly by adopting a burning process or indirectly by first transforming them into secondary fuel as hydrogen, bio-methane, methanol or ethanol. Materials and Methods The present study was conducted using, wheat and rapeseed straws dried at ambient temperature co-digested with fresh cow dung while the total solid content and detention time were kept constant. To conduct the Anaerobic Digestion (AD) experiments, cylinder reactors (13 L) were constructed and placed in a water bath equipped with a heater and sensor to maintain the temperature at 35±2 oC. The biogas produced in the digester was investigated by measuring the displacement of the water in a measuring tube connected to the reactor. Gas samples were obtained from the sampling port and were analyzed gas chromatograph. The temperature for detector, injector and oven were 170, 110 and 50 oC respectively. Before the test, the first CH4 and CO2 net gases, peaks corresponding percentage was determined with respect to the retention time of the area. Then sample was compared with standard gas and samples gas percentage was determined. The residues were mechanically pretreated using a mill in order to increase the availability of the biomass to enzymes. After the pre-treatment, the material (<2 mm) was mixed with a different proportion of fresh cow dung, Initial Total Solids (TS) content in the reactor was adjusted at 9%. Factors such as PH, Volatile Solids (VS) were determined by the standard method. Results and Discussion A decrease in the process pH was observed in the first few days of the digestion and this is due to high volatile fatty acid (VFA) formation. These results were compatible with sanaee moghadam et al. (2013). The results obtained showed that, the highest rate of VS reduction belonged to rapeseed residues at 52.22%.The lowest rate of VS reduction attributed to wheat residues at 36.79%. The rapeseed residues with 311.45 Lit.kg-1 VS had the highest accumulated methane followed by wheat straw with 167.69.28 L.Kg-1 VS in probability level of 5%. The average percentages of methane production for rapeseed straw and wheat straw during the 140 days experiment under mesophilic condition were 66% and 55%, respectively. Production of methane had delay and started after 46th day. Much reason may be possible. Inoculums used in this study were only fresh cattle dung. The mixture of fresh cattle dung and effluent of anaerobic digester or fresh rumen fluid may be decrease retention time and increase biogas production. According results of Budiyono the rumen fluid inoculated to biodigester significantly affected the biogas production. Rumen fluid inoculums caused biogas production rate and efficiency increase more than two times in compare to manure substrate without rumen fluid inoculums (Budyono et al., 2010). The other reason was pretreatment. This study applied just mechanical pretreatment. According to Cecilia studies, different pretreatment combined with mechanical pretreatment decrease retention time and increase biogas production efficiency (Cecilia et al, 2013). However, Zhang et al. claimed that it is hard to say which method is the best because each has its own strong point and weak point. Yet, until now, none of the pretreatment technologies has found a real breakthrough. Conclusions According to this study, rapeseed residues had the highest level of methane production in comparison with wheat residues. The rapeseed residues combine with cattle dung had suitable potential to methane production. The 140 days, Biomaethane Potential (BMP) of rapeseed residues combine with cattle manure had 311. 45 Lit/kg vs. add. Moreover, it had high percentage of VS content reduction (52.22%). The high retention time was observed (140 day). One reason was lack of suitable inoculums and pretreatment. Furthermore, the lingo-cellulose nature of the crop residues, lower will be the biodegrade ability. Furthermore, the anaerobic co-digestion of rapeseed straw with cattle manure is feasible for production of methane.
Authors and Affiliations
M. Safari,R. Abdi,
Keywords
Related Articles
- EP ID EP717819
- DOI -
- Views 50
- Downloads 0
Numerical Study of Wheat Conveying in Separator Cyclone using Computational Fluid Dynamics
IntroductionCyclones are widely used to separate solid particles from the fluid phase. Due to the ease of construction, low running costs, and hard-working conditions at high temperatures, people's interest in using cycl...
Computer Vision Utilization for Detection of Green House Tomato under Natural Illumination
Agricultural sector experiences the application of automated systems since two decades ago. These systems are applied to harvest fruits in agriculture. Computer vision is one of the technologies that are most widely used...
Design, Construction and Test of a Three-point Hitch Dynamometer
For measuring the draft forces exerted by implements into tractor, we use the dynamometers that are divided into pull type or three-point hitch type. For measuring the forces between the tractor and the mounted implement...
Diagnosis of Early Blight Disease in Tomato Plant based on Visible/Near-Infrared Spectroscopy and Principal Components Analysis- Artificial Neural Network Prior to Visual Disease Symptoms
Early diagnosis of plant diseases before the occurrence of symptoms can reduce the loss of the yield and increase the quality of agricultural crops. It also reduces the consumption of pesticides, environmental risks, and...
Challenges and Opportunities in Development of Agricultural Mechanization in Ahvaz County using SWOT Method
IntroductionAgricultural mechanization is defined as the use of energy and production resources, machinery and equipment in agriculture. Modern agriculture is heavily dependent on mechanization, and machinery, equipment,...